behaviour of concrete on replacement of sand

Self-compacting concrete (SCC) behaviour incorporating ...

AbstractOwing to their high intrinsic properties, limestone fines (LF) seems to be a good replacement material of cement and/or sand, elaborating thus a new concrete without affecting its performances and properties. The present work aims at using, however, this natural material as an alternative cement or sand replacement, and investigating its influence on self-compacting concrete (SCC ...

Contact us

Concrete Slab Surface Defects: Causes, Prevention, Repair

sand in the mix. A reduction of 60 to 120 kg of sand per cubic meter of concrete (100 to 200 lb/yd3) may be enough. (Replace the sand removed by adding a like amount of the smallest size coarse aggregate available.) The slightly harsher mix should release most of …

Contact us

BEHAVIOUR OF CONCRETE ON THE USE OF QUARRY DUST TO …

IRACST – Engineering Science and Technology: An International Journal (ESTIJ),ISSN: 2250-3498 Vol. 3, No. 6, December 2013 BEHAVIOUR OF CONCRETE ON THE USE OF QUARRY DUST TO REPLACE SAND – AN EXPERIMENTAL STUDY G.Balamurugan Dr.P.Perumal Associate Professor and Head Principal Department of Civil Engineering Mahendra Institute of Engineering and Technololgy …

Contact us

BEHAVIOR OF CONCRETE ON REPLACEMENT OF SAND …

Concrete cube, beam and cylindrical specimens were tested for evaluation of compressive, flexural and split tensile strength respectively. Workability was measured in terms of slump and compacting factor. The concrete exhibits excellent strength with 60% replacement of natural sand, so it can be used in concrete as viable alternative to natural ...

Contact us

Study On Behaviour Of Concrete Partially Replacing Quartz ...

The paper presents a concrete mix design procedure for partial replacement of sand with quartz sand. Present method was performed to evaluate the additional compressive, flexural strength with higher slump over conventional concrete in which sand is replaced with 0%, 25%, 50% and of quartz sand by weight with 1% super plasticizers.

Contact us

"BEHAVIOUR OF CONCRETE IN THE REPLACEMENT OF …

"BEHAVIOUR OF CONCRETE IN THE REPLACEMENT OF CEMENT AND SAND RESPECTIVELY IN THE DIFFERENT PROPORTION OF POLYMER AND STEEL FIBERS" Alok Kumar Prajapati1, Asst. Prof. Swajit Singh Goud2 1Research Scholar, Dept. of Civil Engineering, Sagar Institute of Science, Technology & Research, Bhopal, India

Contact us

Behaviour of Concrete with Partial Replacement of Cement ...

 · Behaviour of Concrete with Partial Replacement of Cement by Groundnut Shell Ash by "K Dharmendhiran" "R Dhinesh Babu" "S Dhana Bharathi" "M …

Contact us

BEHAVIOUR OF CONCRETE ON THE USE OF QUARRY DUST TO REPLACE …

BEHAVIOUR OF CONCRETE ON THE USE OF QUARRY DUST TO REPLACE SAND - Free download as Powerpoint Presentation (.ppt / .pptx), PDF File (.pdf), Text File (.txt) or view presentation slides online. To use of the quarry dust replacement of fine aggregate reduces the environmental pollution as well as providing an economic value for the waste material.

Contact us

Partial Replacement of Cement With Marble Powder in Concrete

In this paper explained about the behavior of concrete with partial replacement of cement with added percentage values of marble powder and attain required strength. Partial replacement of marble powder in cement accordingly in the range of 20%, 30%, 40%, by weight for M20 grade of concrete.

Contact us

Experimental Study on Properties of Concrete with Partial ...

The design mix proportioning of concrete was done by the Indian Standard Recommended Method IS 10262:2009. The objective mean strength was 31.6MPa for OPC control concrete, the total cement substance in concrete is 380kg/m3, Manufactured Sand is taken 691.58 kg/m3, coarse aggregate is taken 1158kg/m3 the water-cement

Contact us

Effect of partial replacement of sand by fine crumb rubber ...

 · The effect of partial replacement of sand by fine crumb rubber on the impact load performance of concrete was investigated experimentally and numerically. Specimens were prepared for 5, 10 and 20 % replacements by volume of sand. For each case, three beams of size 400 × 100 × 50 mm were loaded to failure in a drop-weight impact machine by subjecting it to 20 N weight from 300 …

Contact us

THE INFLUENCE OF SUPERPLASTICISERS ON THE FRESH AND ...

 · Cellular concrete, superplasticiser, palm oil fuel ash, sand replacement, mechanical behaviour, workability Abstract Since the foam concrete is delicate, it is important to carefully choose the additives, such as superplasticiser (SP), to be used in this type of concrete.

Contact us

STRENGTH AND DURABILITY PROPERTIES OF CONCRETE CONTAINING ...

Common river sand is expensive due to excessive cost of transportation from natural sources. Also large-scale depletion of these sources creates environmental problems. As environmental transportation and other constraints make the availability and use of river sand less attractive, a substitute or replacement product for concrete industry needs to be found.

Contact us

An Experimental Study on Behaviour of Slurry Infilitrated ...

An Experimental Study on Behaviour of Slurry Infilitrated Fibrous Concrete Produced By Partial Replacement of Cement with Fly Ash and Fineaggregate with Robo Sand Chukka Yamini1, V iranjeevi2 PG Scholar (Structural Engineering), Usha Rama College of Engineering and Tech, Telaprolu, AP, India1

Contact us

Behaviour of concrete on replacement of sand with quaries ...

In order to study the strength behaviour and fire resistance of the concrete made with full replacement of sand with Quarry stone dust the tests are conducted. Results so obtained for the tests conducted on cubes and prisms for M25 and M40 grades of concrete with various dosages of super plasticiser at 7days and 28 days were tabulated.

Contact us

Replacement of Sand with Bauxite Mining Waste in Concrete ...

The use of natural sand as fine aggregate in concrete is becoming problematic due to scarcity and pressure on mining of the resource. Alternate sources such as the use of industrial waste as replacement of natural sand in concrete are gaining popularity as a sustainable construction material.

Contact us

Flexural Behaviour of Reinforced Concrete Beams with ...

an optimum replacement percentage of 50% [1].The characteristics of M 30 concrete with partial replacement of cement with GGBS was studied and it was found that the partial replacement of cement with GGBS improves the strength of the concrete substantially compared to normal concrete[2]. The behavior of concrete with GGBS

Contact us

AN INVESTIGATION OF MECHANICAL BEHAVIOUR OF …

BEHAVIOUR OF CONCRETE BY PARTIALLY REPLACING SAND WITH CUPOLA SLAG AND OPC WITH FLY ASH Varun Patel, Dr.P.J.Patel, Umang Parekh . Abstract— Due to growing environmental awareness, as well as stricter regulations on managing industrial waste, the world is …

Contact us

Behaviour of Foam Concrete under Impact Loading Based on ...

Behaviour of Foam Concrete under Impact Loading. 4.2.1. Stress-Strain Curves. The dynamic compression stress-strain curves of the foam concrete specimens with sand with densities of 1,000, 1,200, and 1,400 kg/m 3 are shown for impact velocities of 4.0, 5.0, and 6.0 m/s in Figure 8 – 10.

Contact us

Effect of partial replacement of sand by fine crumb rubber ...

The effect of partial replacement of sand by fine crumb rubber on the impact load performance of concrete was investigated experimentally and numerically. Specimens were prepared for 5, 10 and 20 % replacements by volume of sand. For each case, three beams of size 400 × 100 × 50 mm were loaded to failure in a drop-weight impact machine by subjecting it to 20 N weight from 300 mm height, and ...

Contact us

EXPERIMENTAL STUDY ON E–WASTE CONCRETE AND …

work exhibits that good strength in the concrete with 10% replacement of M20 grade. Also it was replace with the river sand as compared with the control specimen will reduce the essential for conventional coarse aggregates. (Nadhim, et al., 2016) investigated the comparative study on E–plastic waste and fly ash concrete with conventional ...

Contact us

Bond Behavior between BFRP Rebar and Seawater Sea Sand ...

 · Concrete mixed with freshwater and river sand was also prepared for comparison with SWSSC. BFRP rebars with two different surface configurations were selected, that is, ribbed surface and sand-coated surface. Fly ash as a replacement of cement was also investigated in terms of its effect on bond behavior.

Contact us

BEHAVIOUR OF REINFORCED CONCRETE BEAMS WITH COCONUT SHELL ...

 · INTRODUCTION • The high demand for concrete in the construction using normal weight aggregates such as gravel and granite drastically increases the unnecessary weight of concrete.Therefore, there is a need to explore and to find out suitable replacement material to substitute the natural gravel stone strength .

Contact us

Experimental study on the behavior of waste marble powder ...

Experimental study on the behavior of waste marble powder as partial replacement of sand in concrete Abdul Ghani Zeeshan Ali Fasih Ahmed Khan Said Rehan Shah Sajjad Wali Khan Muhammad Rashid The increase in the concrete demand due to the rapid industrialization and urbanization may lead to a shortage of natural resources.

Contact us

Feasibility Study of Fly Ash as a Replacement for Fine ...

replacement of natural sand by fly ash is about 30% as compared to reference mix (0% replacement). 3. It is observed that the residual tensile strength of concrete when subjected to elevated temperature of 200°C for 4 hours, is higher at 40% replacement of natural sand by fly ash. After 40% replacement the tensile strength decreases. The ...

Contact us

USE OF BOTTOM ASH AS FINE AGGREGATE IN CONCRETE: …

aggregate replacement in making concrete when natural sand is expensive to long carrying distance and has high clay content. Utilization of bottom ash as fine aggregate should be studied to alleviate the environmental problem. Bottom ash is collected at the end of the grate in a Waste-to-Energy plant consists of non-combustible

Contact us

Properties of Concrete by Replacement of Natural Sand with ...

The artificial sand have to satisfy the technical requisites such as workability, strength and durability of concrete and hence it has become necessary to study these properties in order to check the suitability and appropriate replacement level of artificial sand in comparison with the natural sand …

Contact us

Study on Behaviour of Concrete by Replacement of Aggregate ...

Study on Behaviour of Concrete by Replacement of Aggregate and Sand with Rubber Tyre Chips and Foundry Sand Abhishek Raulkar1, Vikas 2Khade, Prof. 3J.H. Gurnani, Jayant Anjankar4, Abhishek Wasnik5, Mayuri 6Deo 1Abhishek Raulkar, Department of Civil Engineering, Nagpur Institute of Technology, Nagpur, Maharashtra, India

Contact us

Experimental evaluation of the effort of dune sand ...

province. In order to study the influence of DS replacement levels on the engineering proper-ties of dune sand concrete (DSC) beam, the mechanical properties of DSC and the flexural behaviour of DSC beam were examined with the DS replacement levels ranged from 0% to 80%.

Contact us

Service-Load Behavior of Precast/Prestressed Concrete ...

replacement was based on target NA concrete mixture M-NA4, while the number "5" indicates replacement based on mixture M-NA5. The remaining two numbers on the specimen nomenclature indicate the replacement ratio R, expressed as a percentage (0, 50, or ), and the concrete age at superimposed loading, t o (7 or 28 days), respectively.

Contact us